Reply
 
LinkBack Thread Tools
Old 01-08-2012, 12:39 PM   #1 (permalink)
Junior Member
 
Join Date: Jan 2012
Location: Lakeland, Florida, USA
Posts: 18
Post imported post

Greetings all.My brother just bought ana 86 ASPY with the preverbial erratic idle and slow throttle response at lower RPM's. I am trying to resolve a problem for him. The computer indicates a bad TPS with W steady and 0 + 1 flashing.The FUEL SYSTEM light is ON STEADY . I have read many forum subject post regarding this matter and still cant seem to isolate the cause after throwing many parts and hours at the problem. I am seeking wisdom, guidance and experience from you wingers out there who have been down this same road. This is a long post so bear with me.

PARTS REPLACED OR SUBSTITUTED:

TPS sensorreplaced with a used sensor thatchecked to specs. Reference voltage and return Voltages back to the computer were good. Smooth resistance operation and voltage increase/decrease were smooth and within specs. 3 pin connector male and female replaced. DISCONNECTED TPS 3 PIN CONNECTOR AND STILL GET SAME ECU CODE

FUEL PRESSURE REGULATOR NEW ONE ( AFTER MARKETPR31 )

pbl/pbr swapped with each other and a pair of used ones that I purchased. Vaccum lines to the sensors were replaced.

gl/gr replaced with a new set

NS sensor replaced with NEW / Modified from 85 LTD

ECU SWAPPED: Both ECU's display the same code when the ignition is FIRST switched to ON. Engine NOT Running.

NEW PLUGS

NEW NON-ETHANOL FUEL

Cone filter cleaned at fuel pump inlet

Previous owner had the throttle bodies sync'ed, Modified TPS installed ( I replaced with a used one ) fuel filter replaced, New orings for injector 1, cleaned and tested all injectors, greased all electrical connections on injection harness , compression checked the bike, all GOOD, replaced all exhaust gaskets.

I suspect an electrical signal problem somewhere in the injection harness as I get the code on both ECU's when the key is first turned on but not sure where to go from here. If the bike were running and pressures and flows were involved with the code displayed I obviously would have more to troubleshoot. Talk to me Honda SEI experts! What say ye? Thank you all



























..
cal757 is offline   Reply With Quote
Sponsored Links
Advertisement
 
Old 01-08-2012, 01:28 PM   #2 (permalink)
Senior Banjo Junkie
 
ebanjo's Avatar
 
Join Date: Dec 2008
Location: Antelope Valley, California
Goldwing Model: GL 1000
Posts: 12,951
Garage
Post imported post



Repost this in the Goldwing Technical Forum for a quicker response.
__________________
Happy Trails

5string at bluegrasshighway.com
http://www.live365.com/stations/ebanjo

Glenn
Black 1979 GL1000

PGR Member

“In three words I can sum up everything I've learned about life: It goes on.”
Robert Frost

My pic's
http://www.goldwingfacts.com/forums/...ms-ebanjo.html
ebanjo is offline   Reply With Quote
Old 01-08-2012, 01:34 PM   #3 (permalink)
Senior Member
 
PurplePirate's Avatar
 
Join Date: Jun 2010
Location: Clermont, Indiana, USA
Goldwing Model: 1996 GL1500SE
Posts: 28,517
Garage
Post imported post

Welcome, WelcomeTo Steve Saunders GoldwingForum.If you have any questions no matter how trivial they may seem this forum is the place to ask them. What I have noticed is that some of the people here were 'sin their previous lives and can answer any question you have. Theforums that I get the most from are::

Goldwing Technical Forum

General Motorcycle Discussion Forum


These have the best info aboutGoldwing’s and are where you ask questions and can get help..

For Sale/Wanted ForumGood stuff for Sale or if you have old parts sitting around the garage you would like to get rid of....





And when all you need is a good laugh to start your day try the:: Fun Forum After that it’s up to you which of the others you will like the best all I can do is suggest.

Again Welcome to the Forum...

Oh and did I mention everyone here loves pictures.. Show us some of yours... Even if it’s not a Goldwing just a pretty view
__________________
Any sufficiently advanced technology is indistinguishable from magic.
~ Arthur C. Clarke ~

Always look for the door "C" it may be hidden but there is always one there...
PurplePirate is offline   Reply With Quote
Old 01-08-2012, 04:38 PM   #4 (permalink)
Gregarious Greeter
 
SETHAN12's Avatar
 
Join Date: Mar 2009
Location: Liberty, Pennsylvania, USA
Goldwing Model: GL 1800
Posts: 16,806
Garage
Post imported post

[align=center]
[/align]
[align=center]Welcome cal757[/align]
__________________
Yesterday is for memories!
Today is for making memories!
Tomorrow is a concept that does not exist!
What are you waiting for? ... Sam-n-Elaine
Just livin\' the dream!!!!!
Just another day in paradise!!!!!
Honor above all else!!!!!
Thank you Dylan Saunders for the layout of my greeting!!!!
SETHAN12 is offline   Reply With Quote
Old 01-08-2012, 04:39 PM   #5 (permalink)
Senior Member
 
Rocketman911's Avatar
 
Join Date: Mar 2011
Location: TENNESSEE VALEY AREA!, Alabama, USA
Goldwing Model: 1800
Posts: 28,747
Post imported post

WELCOME
__________________
http://www.goldwingfacts.com/forums/...big-249685.gif

Naysayer: Someone who is more confused than a drunk, mentally challenged termite in a YoYo!
Rocketman911 is offline   Reply With Quote
Old 01-08-2012, 04:39 PM   #6 (permalink)
Senior Member
 
lionelgo50's Avatar
 
Join Date: Sep 2009
Location: Oklahoma City, , USA
Posts: 7,703
Post imported post

Welcome from Oklahoma Enjoy the wing

__________________
Dave
Ride Safe and Ride Often, Keep the Shiny Side up and Many Happy Miles and Smiles.

"In God We Trust" All Others Must pay Cash!!!

Current Goldwing 2010 Gl1800 Trike Caliente Red
1997 GL1500 SE Pearl Sonoma Green

Other Rides

2012 Harley Davidson Heritage Softail
2007 Honda 110cc

Past Rides

2 1985 Goldwing Aspencades, 2006 Harley Davidson Sportster 1200, 2006 Goldwing Navi, 2007 Honda Rebel, 1994 1500cc Goldwing Interstate
lionelgo50 is offline   Reply With Quote
Old 01-08-2012, 06:31 PM   #7 (permalink)
Senior Member
 
Xzebra's Avatar
 
Join Date: Mar 2010
Location: Sebastian, Florida, USA
Posts: 4,415
Post imported post


__________________
Larry
My wing is my Fountain of Youth
Proud Member Patriot Guard Riders
Xzebra is online now   Reply With Quote
Old 01-08-2012, 08:07 PM   #8 (permalink)
Senior Member
 
Doug D's Avatar
 
Join Date: Oct 2007
Location: Fort Wayne, Indiana, USA
Goldwing Model: 1999 GL 1500A Black 52,XXX and climbing
Posts: 5,220
Garage
Post imported post

[align=center]Welcome to the greatest forum on the net

Welcome from the "HOOSIER" state
[/align]
__________________
DD & da Boiz
God is great, Beer is good, & People are crazy!
GWRRA #296368
Indiana Patriot Guard
Every day above ground is a GOOD day!
Doug D is offline   Reply With Quote
Old 01-09-2012, 06:16 AM   #9 (permalink)
Senior Member
 
Crazy Dog's Avatar
 
Join Date: Sep 2007
Location: Staffs/Cheshire border, , United Kingdom
Posts: 8,371
Garage
Post imported post

Warm welcome to you buddy
__________________
Be strong at all times
Crazy Dog is offline   Reply With Quote
Old 01-09-2012, 11:22 AM   #10 (permalink)
Super Moderator
 
Flyone's Avatar
 
Join Date: Aug 2006
Location: Newnan, GA, USA
Goldwing Model: 2012 GL-1800
Posts: 20,473
Garage
Send a message via Skype™ to Flyone
Post imported post

WElcome to the Forum cal757!
__________________
2012 GL-1800,2001 Cycle Mate CM2000 LTD Trailer
PM of Northstar Lodge #168, Wichita, KS 2B1ASK1, Midian Shriner, AOPA, Founding member of Wild Rhinos and KANWINGS
NASSIR 5 Host - which was an honor and pleasure to serve the members of this forum.
RIP Pop Fly
Flyone is offline   Reply With Quote
Sponsored Links
Advertisement
 
Reply

  Steve Saunders Goldwing Forums > Forums > New Members Introduction Forum

Thread Tools

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
need expert on LTD/SEI fuel injection JerryH Goldwing Technical Forum 20 08-05-2011 09:21 PM
1986 GL1200 SEI FUEL PUMP bigted$$ Goldwing Technical Forum 4 03-15-2011 09:04 AM
1986 gl1200 sei fuel pump sctrucker Goldwing Technical Forum 5 03-10-2011 09:42 AM
87 1200 fuel injection problem punkincycle Goldwing Technical Forum 7 04-08-2010 03:29 PM
Fuel Injection Conversion for 1986 Aspencade WyoWinger Goldwing Technical Forum 2 03-15-2005 05:57 PM


All times are GMT -4. The time now is 07:23 PM.


Powered by vBulletin® Copyright ©2000 - 2014, Jelsoft Enterprises Ltd.
SEO by vBSEO 3.6.0 PL2
Garage Plus vBulletin Plugins by Drive Thru Online, Inc.
Shoutbox provided by vBShout v6.2.1 (Lite) - vBulletin Mods & Addons Copyright © 2014 DragonByte Technologies Ltd. Runs best on HiVelocity Hosting.
Motorcycle News, Videos and Reviews
Honda Grom Forum Harley Davidson Forum Honda 600RR Forum Kawasaki Forum Yamaha R6 Forum Yamaha FZ-09 Forum
1199 Panigale Forum Roadglide Forum Honda CBR1000 Forum Vulcan Forum Yamaha R1 Forum Yamaha R3 Forum
Ducati Monster Forum Harley Forums Honda CBR250R Forum ZX10R Forum Star Raider Forum Yamaha Viking Forum
Suzuki GSXR Forum V-Rod Forums Honda Shadow Forum Kawasaki Motorcycle Forum Star Warrior Forum KTM Duke 390 Forum
SV650 Forum BMW S1000RR Forum Honda Fury Forum Kawasaki Versys Forum Drag Racing Forum Ducati 899 Panigale Forum
Suzuki V-Strom BMW K1600 Triumph Forum Victory Forums Sportbikes BMW NineT Forum
Volusia Forum BMW F800 Forum Triumph 675 Forum MV Agusta Forum HD Street Forum Suzuki GW250 Forum
Yamaha Motorcycles Victory Gunner Forum Honda Vultus Forum HD LiveWire Forum Ninja H2 Forum Ducati Scrambler Forum Kawasaki Ninja 250SL Forum